kawa-ultrarepair-manual – Ebook download as PDF File .pdf), Text File .txt) or Kawasaki “JET SKI” watercraft are introduced by the Special Tool Manual. Here ya go Attached Files. File Type: pdf Kawasaki JET SKI Ultra pdf ( MB, views). Yamaha FZR Kawasaki STXF. Owner’s Manual – Page # Posted on 12 Sep, Model: Kawasaki Jet Ski Ultra Pages: File size: 9 MB. Download Manual. Online Viewer.

Author: Shakinos Yokazahn
Country: Iceland
Language: English (Spanish)
Genre: Spiritual
Published (Last): 10 February 2005
Pages: 489
PDF File Size: 18.4 Mb
ePub File Size: 6.86 Mb
ISBN: 850-9-18151-853-4
Downloads: 10750
Price: Free* [*Free Regsitration Required]
Uploader: Telkree

Apply high grade water-resistance grease. Technical Information-kawasaki Smart Steering System carburetor Type – the throttle is released completely – and the kawasski are held fully to the left or right. Pull the lanyard key off the stop kawasak.

Apply synthetic rubber adhesive. Exhaust gases contain carbon monoxide, a colorless, odor- less, poisonous gas. Oil Pump Cable 7. Page 18 New counter balancers, one at each end of the crankshaft, decrease vibrations and make this the smoothest running Kawasaki triple ever produced.

The antiknock index is posted on service station pumps. Apply manaul rubber adhesive L: The JHB1 has a mixed flow pump. If the Coil Tester is not available, the coil can be checked for a broken or badly shorted winding with a hand tester.


kawasaki ultra service manual

Connect the inlet air temperature sensor lead to the main harness. Choke Knob Shaft B. Pump Two kinds of pump are used in PWC for propulsion.

Comparison of Cylinders Nikasil Plating: UltraJhb1Jhb2Jhb3. Fuel Vent Line 5. This information shown here represents results under controlled maual, and the information may not be correct under other conditions.

To the oil level gauge.

The fuel vent check valve must be mounted so that the arrow is pointing toward the fuel tank. Overheat Control 5 Engine Over-Rev Cut-Off The igniter stops ignition when engine speed exceeds 7 rpm, to protect the engine from dam Standard Point Transom 2. Attaching the fuel vent pipe to the 4.

If the clutch does not operate as it should or if it makes noise, disassemble the starter clutch, examine each part visually, and replace any worn or damaged parts.

Initial torque for temporal tightening MO: Replace the rear cover assembly. To the smart steering actuator.

After engine reassembly, the front and rear balancer oil chambers must be refilled with engine oil for lubricating the bearings and teeth, since these chambers are isolated from crankcase chambers. Fuel Vent Hose Length: Rear Check Valve 3. Rare earth metal magnets lighten the magneto and decrease the flywheel effect, improving acceleration response. Lubrication As in all marine craft, adequate lubrication and corrosion protection is an absolute necessity to provide long, reliable Finish the application of the liquid gasket within 30 min- utes.


Torque – Spark Plugs: Breathing exhaust gas leads to carbon monoxide poisoning, asphyxiation, and death. High Altitude Performance Adjustment Got it, continue to print. If the 105 or cable housing ulhra kinked or frayed, replace the cable.

2001 Kawasaki Jet Ski Ultra 150 — Owner’s Manual – Page #26

To replace a rubber part, use a cement in the following table, or an equivalent. The throttle sensor signal goes to the igniter. If necessary adjust the steering cable. Cooling and Bilge System Hoses Comments to this Manuals Your Name. Harsh solvents may attack manuwl surface or smear the colors.

However, a hand tester can not detect layer shorts and shorts resulting from insulation breakdown under high volt- age. Replace the starter motor with a new one if the commu- tator diameter is less than the service limit.